Advertise on DISCO4.COM
Forum · Gallery · Wiki · Shop · Sponsors
DISCO4.COM > Webasto Fuel Burning Heater

Robbie's Guide To FBH Servicing & Repair
Post Reply  Down to end
Page 4 of 17 <123 45 ... 151617>
John C
 


Member Since: 28 Aug 2007
Location: East Yorkshire
Posts: 3291

United Kingdom 2006 Discovery 3 TDV6 SE Auto Cairns BlueDiscovery 3

Sorry for the basic question. I'm wondering if my fuel line is blocked a bit. How do you remove the fuel pipe? I can't see how the clamps on the fuel pioe works. Do you just use pliers?
 2020 SDV6 D5 HSE, Carpathian Grey +
2022 Tesla Model Y LR... almost Carpathian Grey
Previously : 2005 TDV6 SE Auto, Cairns Blue (288K) - ours for 16 years 
 
Post #161337020th Feb 2016 9:49 pm
View user's profile Send private message View poster's gallery Reply with quote
DiscoJake
 


Member Since: 23 Aug 2013
Location: Hereford
Posts: 1429

United Kingdom 2009 Discovery 3 TDV6 HSE Auto Stornoway GreyDiscovery 3

Technically special pliers to remove but mole grips will do.
The clamp will be ruined after and you'll need jubilee clips to replace Thumbs Up
  
Post #161337220th Feb 2016 9:59 pm
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
Robbie
 


Member Since: 05 Feb 2006
Location: ¯\_(ツ)_/¯
Posts: 17932

United Kingdom 2013 Discovery 4 3.0 SDV6 HSE Auto Baltic BlueDiscovery 4

I think it's a single ear crimp, so you just snip off the bit that sticks out. I'm not a huge fan of jubilee clamps for this application, but I am the cautious type with fuel pipes. I usually crimp on a new double ear crimp, but a good sprung clamp would also do.

Thumbs Up
 Land Rover - Turning Drivers into Mechanics Since 1948

Battery & Quiescent Current Drain Testing

Diagnostics for:
Defender, FL2, D3, D4, Evoque, RRS & FFRR
A not-for-profit enterprise


 
 
Post #161337920th Feb 2016 10:16 pm
View user's profile Send private message View poster's gallery Reply with quote
John C
 


Member Since: 28 Aug 2007
Location: East Yorkshire
Posts: 3291

United Kingdom 2006 Discovery 3 TDV6 SE Auto Cairns BlueDiscovery 3

Thank you!
 2020 SDV6 D5 HSE, Carpathian Grey +
2022 Tesla Model Y LR... almost Carpathian Grey
Previously : 2005 TDV6 SE Auto, Cairns Blue (288K) - ours for 16 years 
 
Post #161342421st Feb 2016 6:45 am
View user's profile Send private message View poster's gallery Reply with quote
Madrilleno
 


Member Since: 13 Oct 2014
Location: Nottingham
Posts: 1742

England 2012 Discovery 4 3.0 SDV6 HSE Auto Santorini BlackDiscovery 4

Robbie, do you have a list of seals and gaskets, and a source for them? Need to strip and clean mine properly - the oxygen only gets it going again for a little while - and I want to get a full set of seals and gaskets before I start.

Thanks,

Madrilleno
 There are two rules for success,
1. Never tell everything you know.



RLD Spare Wheel Protector
RLD Sump Guard
Narpy Style RRS Grille from Beanie
Discostick 3rd button FBH controller
IID BT
EGRs Blanked
Geoff Gearbox Flush
Prospeed sliders & compressor guard 
 
Post #161530524th Feb 2016 10:06 am
View user's profile Send private message View poster's gallery Reply with quote
Robbie
 


Member Since: 05 Feb 2006
Location: ¯\_(ツ)_/¯
Posts: 17932

United Kingdom 2013 Discovery 4 3.0 SDV6 HSE Auto Baltic BlueDiscovery 4

The workshop manual is in my gallery:

http://media.disco3.co.uk/gallery/albums/u...op_V~0.pdf

Parts from eBay, a truck garage or local marina (LR dealer would usually be expensive).

Thumbs Up
 Land Rover - Turning Drivers into Mechanics Since 1948

Battery & Quiescent Current Drain Testing

Diagnostics for:
Defender, FL2, D3, D4, Evoque, RRS & FFRR
A not-for-profit enterprise


 
 
Post #161531524th Feb 2016 10:27 am
View user's profile Send private message View poster's gallery Reply with quote
Madrilleno
 


Member Since: 13 Oct 2014
Location: Nottingham
Posts: 1742

England 2012 Discovery 4 3.0 SDV6 HSE Auto Santorini BlackDiscovery 4

Thanks Thumbs Up
 There are two rules for success,
1. Never tell everything you know.



RLD Spare Wheel Protector
RLD Sump Guard
Narpy Style RRS Grille from Beanie
Discostick 3rd button FBH controller
IID BT
EGRs Blanked
Geoff Gearbox Flush
Prospeed sliders & compressor guard 
 
Post #161532424th Feb 2016 10:46 am
View user's profile Send private message View poster's gallery Reply with quote
Dai-Disco3
 


Member Since: 30 Nov 2014
Location: Southend on Sea
Posts: 180

United Kingdom 2009 Discovery 3 TDV6 HSE Auto Stornoway GreyDiscovery 3

Robbie, all
Can find the main gasket and o rings on line, but cannot see the very thin paper like gaskets, for when you strip the burner. Is their part numbers for these, or do you only strip this if you really need to?

Only for interest at the moment as mine is working fine at the moment Whistle
  
Post #161533024th Feb 2016 11:04 am
View user's profile Send private message View poster's gallery Reply with quote
Robbie
 


Member Since: 05 Feb 2006
Location: ¯\_(ツ)_/¯
Posts: 17932

United Kingdom 2013 Discovery 4 3.0 SDV6 HSE Auto Baltic BlueDiscovery 4

The gaskets can be purchased but I see no need to pull apart the burner when cleaning / servicing the FBH. If I suspected that the metal cup was knackered I would pull it apart to check as not all of it is visible through the glowplug hole. Otherwise after giving it a clean I just check that the fuel can run freely and that the glowplug resistance is within the correct range.

Thumbs Up
 Land Rover - Turning Drivers into Mechanics Since 1948

Battery & Quiescent Current Drain Testing

Diagnostics for:
Defender, FL2, D3, D4, Evoque, RRS & FFRR
A not-for-profit enterprise


 
 
Post #161533224th Feb 2016 11:13 am
View user's profile Send private message View poster's gallery Reply with quote
Madrilleno
 


Member Since: 13 Oct 2014
Location: Nottingham
Posts: 1742

England 2012 Discovery 4 3.0 SDV6 HSE Auto Santorini BlackDiscovery 4

Robbie, the o-rings are simple to source, but the purpose made gasket referred to in the manual as part E is not available. Did you manage to source one, or does the gasket from a different model fit on the V?


 There are two rules for success,
1. Never tell everything you know.



RLD Spare Wheel Protector
RLD Sump Guard
Narpy Style RRS Grille from Beanie
Discostick 3rd button FBH controller
IID BT
EGRs Blanked
Geoff Gearbox Flush
Prospeed sliders & compressor guard 
 
Post #161533324th Feb 2016 11:13 am
View user's profile Send private message View poster's gallery Reply with quote
Madrilleno
 


Member Since: 13 Oct 2014
Location: Nottingham
Posts: 1742

England 2012 Discovery 4 3.0 SDV6 HSE Auto Santorini BlackDiscovery 4

I think a couple of posts appeared before my last one. Question repeated - sorry.
 There are two rules for success,
1. Never tell everything you know.



RLD Spare Wheel Protector
RLD Sump Guard
Narpy Style RRS Grille from Beanie
Discostick 3rd button FBH controller
IID BT
EGRs Blanked
Geoff Gearbox Flush
Prospeed sliders & compressor guard 
 
Post #161533624th Feb 2016 11:15 am
View user's profile Send private message View poster's gallery Reply with quote
Martin
Site Admin and Owner 


Member Since: 06 Nov 2004
Location: Hook Norton
Posts: 18439

United Kingdom 2006 Discovery 3 TDV6 SE Manual Buckingham BlueDiscovery 3

Martin wrote:
The main gasket and 2 O-rings are available from LR as part number LR004141 for about £5

4th reply in this thread Wink
 06 D3 SE / 15 LR D90 XS SW / 88 LR 90 Td5 / 68 BMW 2000 ti
Any issues with the site let me know! 
 
Post #161533724th Feb 2016 11:15 am
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
Robbie
 


Member Since: 05 Feb 2006
Location: ¯\_(ツ)_/¯
Posts: 17932

United Kingdom 2013 Discovery 4 3.0 SDV6 HSE Auto Baltic BlueDiscovery 4

I got a packet of them from the local marina.
 Land Rover - Turning Drivers into Mechanics Since 1948

Battery & Quiescent Current Drain Testing

Diagnostics for:
Defender, FL2, D3, D4, Evoque, RRS & FFRR
A not-for-profit enterprise


 
 
Post #161533824th Feb 2016 11:16 am
View user's profile Send private message View poster's gallery Reply with quote
Martin
Site Admin and Owner 


Member Since: 06 Nov 2004
Location: Hook Norton
Posts: 18439

United Kingdom 2006 Discovery 3 TDV6 SE Manual Buckingham BlueDiscovery 3

LR004141 contents:

 06 D3 SE / 15 LR D90 XS SW / 88 LR 90 Td5 / 68 BMW 2000 ti
Any issues with the site let me know! 
 
Post #161533924th Feb 2016 11:16 am
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
Madrilleno
 


Member Since: 13 Oct 2014
Location: Nottingham
Posts: 1742

England 2012 Discovery 4 3.0 SDV6 HSE Auto Santorini BlackDiscovery 4

Thumbs Up
 There are two rules for success,
1. Never tell everything you know.



RLD Spare Wheel Protector
RLD Sump Guard
Narpy Style RRS Grille from Beanie
Discostick 3rd button FBH controller
IID BT
EGRs Blanked
Geoff Gearbox Flush
Prospeed sliders & compressor guard 
 
Post #161534024th Feb 2016 11:19 am
View user's profile Send private message View poster's gallery Reply with quote
Display posts from the last:  
Post Reply Back to top
Page 4 of 17 <123 45 ... 151617>
Jump to:  
Previous Topic | Next Topic >


Posting Rules
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum



DISCO4.COM Copyright © 2004-2024 Futuranet Ltd & Martin Lewis
DISCO3.CO.UK RSS Feed - All Forums

DISCO4.COM is independent and not affiliated to Land Rover.
Switch to Mobile Site