Member Since: 08 Mar 2006
Location: Middle England!
Posts: 810
Could there be a monkey bike under my bonnet?
OK - either Land Rover have secretly snuck out and modified my D3 by fitting a monkey bike under the bonnet linked to the throttle, perhaps as some precursor / test bed for their forthcoming supplementary electric motor. Only trouble is, it's making quite a lot of noise, but not delivering any performance benefits. OR something's not right with my D3!
At speeds above about 15/20 mph there is a noise coming from what sounds like somewhere near the front near-side wheel. It almost sounds like a piece of trim rubbing on the tread of the tyre or similar - but I'm sure nothing is touching the wheel. At times there's also almost a resonant quality to the sound and it sounds a bit like an exhaust leak - but I can't hear it at slow speeds or when stopped. It seems to be more linked to road speed, than engine speed.
It therefore seems to me that it may well be in some way be transmission / drive / wheel related. Either that or the 'monkey bike supplementary power option' still needs quite a bit of work.
Any ideas anyone?
ThanksD4 XS MY12 Galway
24th May 2010 2:49 pm
crwoody
Member Since: 09 Mar 2009
Location: Littleborough
Posts: 2109
Front wheel bearing?
Does the noise get more pronounced as you turn into a bend, (increasing the sideways force on it.)
I've just replaced mine for making a similar sound to what you describe. The give-away was when I jacked up that corner and found I could move the wheel a few mm by grabbing it top & bottom and "wobbling" it.Clive
24th May 2010 5:05 pm
Calcul@tor
Member Since: 08 Mar 2006
Location: Middle England!
Posts: 810
Wheel bearing is something I've been thinking about. I haven't noticed it getting worse on cornering - but will pay attention tonight.
If it is - could it fail in a big way and cause either damage or worse, danger, say on a motorway? Did you change yours? Was it easy? Any guide on cost of parts?
Could a bearing also give a resonant 'quality' to the sound?
ThanksD4 XS MY12 Galway
24th May 2010 5:38 pm
crwoody
Member Since: 09 Mar 2009
Location: Littleborough
Posts: 2109
I suppose you could describe it as "resonant" certainly the rhythm/frequency related to road speed, could be a complete red herring of course.
As I say, the best way to check is to lift the offending corner and see.
If you do need one, the bearings come as a complete pre-assembled hub for about £100, not available separately.
It's not that bad of a job to do though, an hour or so maybe. The longest part for me was removing the M10 countersunk bolt that holds the brake disc onto the flange, ended up having to drill it out after mangling two T50 bits on it .
First undo the big centre nut (32mm socket and a BIG breaker bar,) and the disc fixing bolt while someone stands on the brake pedal, then unbolt the caliper, then the disc and caliper come and off there are four M12 bolts (with 15mm heads) holding the hub onto the outer part, from behind, then you'll need a punch and a fairly heavy hammer to knock the splined end of the CV joint back into the centre of the bearing.
The torque setting for the centre hub is 350nM I believe, since my biggest torque wrench only goes up to 240, I used the "Fat bloke on a big bar" method, not very scientific I know but it compares to the effort required to undo it.
Edited to add; I took mine on a round trip of about 800 miles just before I changed it (because I didn't have time to do it before) with no big drama, but I would strongly advise checking it asap so at least you know what you're up against. If it gets worse you should hear it screaming before it seizes up altogether.
Edited again; Part number for the hub is RFM500010Clive
24th May 2010 6:36 pm
Calcul@tor
Member Since: 08 Mar 2006
Location: Middle England!
Posts: 810
Many thanks for all of that!
I'm not sure whether it's the bearing or not - but it gives me somewhere to start and check first. Oddly, it doesn't seem to get worse cornering, but maybe increases slightly under acceleration - although is definitely road speed related rather than engine speed.D4 XS MY12 Galway
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum